TM 5-3895-373-10
CHAPTER 3
MAINTENANCE INSTRUCTIONS
Page
SECTION I
LUBRICATION INSTRUCTIONS .............................................................................. 3-1
SECTION
II
TROUBLESHOOTING PROCEDURES ............................ ........................................ 3-1
3.1
Introduction ........................................... ............................................................. 3-1
3.2
Troubleshooting ...................................... .. ....................................................... 3-3
SECTION III
OPERATOR MAINTENANCE INSTRUCTIONS .................... . .............................. 3-18
3.3
Introduction ........................................... ........................................................... 3-18
SECTION I. LUBRICATION INSTRUCTIONS
All lubrication of the 780T Bituminous Asphalt
Paving Machine shall be in accordance with
Lubrication Order, LO 53895-373-12.
SECTION II. TROUBLESHOOTING PROCEDURES
3.1 INTRODUCTION.
Table 3-1 contains troubleshooting procedures for
locating and correcting most operating troubles, which
are the responsibility of the operator. Each malfunction
for a component or system is followed by a list of tests or
inspections that will help determine probable causes and
corrective actions to take. Perform the tests, inspections,
and corrective actions in the order listed.
This manual cannot list all possible malfunctions that can
occur nor all tests or inspections and corrective actions.
If a malfunction is not listed, or if a malfunction is not
fixed by corrective actions listed, contact the supervisor.
Only those functions within the scope of operator
maintenance are listed.
Refer to the malfunction index on the following page.
Locate the malfunction that is the same or most nearly
the same as the trouble occurring with the paving
machine. The malfunction index lists the malfunction
number of the troubleshooting information for that
problem
and
references
the
page
number
for
troubleshooting information. Follow the troubleshooting
steps one by one and perform the corrective actions
listed.
3-1
